Used Bulk Bag Glue Bag Sealers

Stock# 71841002

Used- American Newlong Model PBC-8W Double Pinch Bag Heat Sealer. The PBC-W is a double pinch unit. This machine utilizes a hot air preheat station, a series of heater bars (# of bar sets dependent on required dwell time), and a compression wheel to fuse an inner seal of a multi-wall paper bag with a poly liner. This model also utilizes a creasing wheel to define a consistent fold line and a hot air manifold to activate the pre-applied hot melt adhesive. The bag top folding section will complete the fold and transfer the bag to a non-stick compression belt section. The end result is a well fused inner seal supported by a high strength fold over seal. The temperature is easily adjusted and monitored for best results. The air intake is regulated and digitally monitored for correct pressure. An alarm will be activated if either the heat or the air is out of range and the sealer will automatically shut down to avoid machine damage or bad seals. The bag carrier chain is supported by fixed and spring loaded chain guides. This design prevents bag tops from slipping and / or shifting during the sealing process. Includes belt conveyor approximate 12" Wide x 28' Long.

Stock# 71408001

Used- Doboy (Bosch) Model GS1000 XL Paper Bag Sealer. Machine is rated at speeds up to 75 bags per minute. Has a bag width range of 3.5" minimum to 15" maximum. Is capable of sealing 3 to 20 pound bags (larger bags may require modifications) gussetted, multi-wall, and inner liner seal. Has an adjustable height crank for a range of 35" to 79". Uses a Nordson ProBlue 10 hot melt glue unit with one hose and a single head applicator. Uses Direct Logic 06 PLC control system. 25 Amp. 3/60/460V.

Stock# 72228014

Used-Fischbein DRC 300 Double Roll Bag Closer, Right to Left. Model: DRC 300 DRC0LL000010, Double Toll Closure, w/ hot glue seal. ITW Dynatec hot glue pot. Variable speed controls, max speed: 80 ft./min. Bag trimmer station. Electric raise and lower. Auto and manual modes, mild steel frame, on casters. 208V, 3 Phase, 60 Hz, 2.4 Amp, 90 PSI, Overall Dimensions: 80 in. long x 48 in. wide x 74 in. tall

Stock# 72449004

Used- Pacemaker Unibagger Bag Loading and Sealing System. Rated up to 30 bagged/sealed packages per minute, depending on operator and product. 15" Wide seal jaw. Approximate bag sizes from 1" to 15" wide x 3" to 19-1/2" long x maximum 4" thick. Includes inclined cleated belt conveyor, Baldor VS drive. 350 Watt. All mounted on a single frame. Bag loader serial# 10603. Bag sealer serial# 4574. 1/60/115 Volt.